New Airbag Woes
08-11-2011, 07:15 AM
#1
AudiWorld Member
Thread Starter
Join Date: Sep 2005
Posts: 142
Likes: 0
Received 0 Likes
on
0 Posts
New Airbag Woes
Happy new 2012 S4 owner here, see how i toiled and got to
the right connections to activate horn, backlight, and MFC:
http://www.audizine.com/forum/showth...-Kandiru/page2
After installing an Audi round airbag # 8J0 880 201 J 6PS to
compliment my R8 V10 steering wheel i get following problems:
1. AIRBAG light on tachymeter
2. "Parking Brake Failure" on center display, but electronic
e-brake works just fine.
Assuming i got the wiring right, see link above for the order
i put them in, is it possible that all i need is to follow the
procedure here to allow the controller to recognize new airbag?
http://www.ross-tech.com/vag-com/car...ag-coding.html
Or am i dealing with a faulty or miswired airbag? Those who know can check my pinouts on page 1 of above post:
http://www.audizine.com/forum/showth...-Kandiru/page1
Also, if i clear codes and reassign the 2 digit "Airbag Index", will the codes come back if the bag where truly defective?
Your input much apprecited, i will fire up VCDS tonight and look around the modules. VCDS virgin BTW
the right connections to activate horn, backlight, and MFC:
http://www.audizine.com/forum/showth...-Kandiru/page2
After installing an Audi round airbag # 8J0 880 201 J 6PS to
compliment my R8 V10 steering wheel i get following problems:
1. AIRBAG light on tachymeter
2. "Parking Brake Failure" on center display, but electronic
e-brake works just fine.
Assuming i got the wiring right, see link above for the order
i put them in, is it possible that all i need is to follow the
procedure here to allow the controller to recognize new airbag?
http://www.ross-tech.com/vag-com/car...ag-coding.html
Or am i dealing with a faulty or miswired airbag? Those who know can check my pinouts on page 1 of above post:
http://www.audizine.com/forum/showth...-Kandiru/page1
Also, if i clear codes and reassign the 2 digit "Airbag Index", will the codes come back if the bag where truly defective?
Your input much apprecited, i will fire up VCDS tonight and look around the modules. VCDS virgin BTW
Last edited by Kandiru; 08-11-2011 at 07:28 AM.
08-20-2011, 09:51 AM
#3
AudiWorld Member
Thread Starter
Join Date: Sep 2005
Posts: 142
Likes: 0
Received 0 Likes
on
0 Posts
OK, brand new airbag, same part number with an "L" instead of the J before the final 3 digits and a nice silver ring around the 4 rings, same errors, i am desperate.
On the bright side it appears that the ABS and Parking Brake errors are related to the airbag, so i did not fry any modules. I did insert the key all the way in again every time after battery disconnect.
From what i read faulty wiring can do this, but i did my best using VAG specific tools to repin the new airbag into the S4 connector.
I have full horn, MFC, but get Airbag and Parking Brake Malfunction errors.
HELP!!!
$349 later, here is the spitout, FYI the intermittent contact at radio went away after i stuffed soft wire insulation into the purple retaining rod's tract, no way it could be reinserted without fracture after the brutal pin extractions, i also rechecked the pins for shorts and contact:
Saturday,20,August,2011,13:27:44:39785
VCDS Version: Release 10.6.4
Data version: 20110418
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 8T0
Scan: 01 03 05 08 09 15 16 17 19 22 2E 36 42 46 47 52 53 55 56 62
72 77
VIN: WAUDGBFL2CA017467 Mileage: 480km/298miles
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CCBA) Labels: None
Part No SW: 8K0 907 551 D HW: 8K0 907 551 A
Component: 3.0T SIMOS84 H08 0001
Revision: --H08---
Coding: 0104000A180F0128
Shop #: WSC 06324 000 00000
ASAM Dataset: EV_ECM30TFS0218K0907551D 001001
ROD: N/A
VCID: 32611EB2D4BF
No ASAM data for: "EV_ECM30TFS0218K0907551D" (AU48)
No fault code found.
Readiness: 1110 1101
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 8K0-907-379.clb
Part No SW: 8K0 907 379 BJ HW: 8K0 907 379 BJ
Component: ESP8 quattro H04 0060
Revision: -------- Serial number: --------------
Coding: 280D1A
Shop #: WSC 06324 000 00000
VCID: 82010E72A49F
1 Fault Found:
00473 - Control Module for Elect. Park/Hand Brake (J540)
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01101101
Fault Priority: 6
Fault Frequency: 1
Reset counter: 25
Mileage: 482 km
Time Indication: 0
Date: 2010.01.22
Time: 00:45:21
Freeze Frame:
Hex Value: 0x0000
Hex Value: 0x4782
Hex Value: 0x0032
Hex Value: 0x02AE
Hex Value: 0x00FF
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels: 8K0-907-064-05.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001
Coding: 0B0100
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8T0 959 754 AD HW: 8T0 959 754 AD
Component: FBSAUDIB8 IDG H60 0072
Part No SW: 8K0 905 852 D HW: 8K0 905 852 D
Component: J764 ELV MLB H37 0042
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: Redir Fail!
Part No SW: 8T1 820 043 AQ HW: 8T1 820 043 AQ
Component: KLIMA 3 ZONEN H08 0180
Revision: C1000000 Serial number: 01220620110698
Coding: 66002000
Shop #: WSC 06325 000 00000
VCID: 8005047AAA93
1 Fault Found:
01206 - Signal for Duration of Ignition Off Time
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 7
Fault Frequency: 1
Reset counter: 65
Mileage: 482 km
Time Indication: 0
Date: 2010.01.22
Time: 00:00:55
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 8K0-907-063.clb
Part No SW: 8K0 907 063 P HW: 8K0 907 063 P
Component: BCM1 1.0 H30 0392
Revision: 10030001 Serial number: 00000000952773
Coding: 26001091063CAF212600080300003D0D0F1C92480201016100 0000
Shop #: WSC 06325 000 00000
VCID: 3C7D308A06FB
Part No SW: 8K1 955 119 A HW: 8T1 955 119
Component: WWS 220611 H07 0070
Coding: 00FD11
Part No SW: 8K0 955 559 HW: 8K0 955 559
Component: RLS H04 0003
Coding: 025028
Part No SW: 8K0 941 531 AS HW: 8K0 941 531 AS
Component: E1 - LDS H03 0031
Part No SW: 8K0 907 410 C HW: 8K0 907 410 C
Component: HOMELINK H01 0010
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 8K0-959-655.clb
Part No SW: 8K0 959 655 K HW: 8K0 959 655 K
Component: AirbagVW-AU10 H44 0610
Serial number: 003GLD0NN7CW
Coding: 303937354230303030304A55304C384B3053
Shop #: WSC 06325 000 00000
ASAM Dataset: EV_AirbaECUVWAUDI010 003010
ROD: EV_AirbaECUVWAUDI010_AU48.rod
VCID: 458B556E7531
Seat occupied recognition:
Part No SW: 8K0 959 339 C HW: 8K0 959 339 C
Component: BF-Gewichtss. H02 0040
Serial number: 5810000R11000045GK
Driver's Airbag Crash Sensor:
Serial number: 6334MSME611555512
Passenger Side Airbag Crash Sensor:
Serial number: 6344MSME5F66246CU
Driver's Rear Airbag Crash Sensor:
Serial number: 6352QSME240C2B7AP
Passenger's Rear Airbag Crash Sensor:
Serial number: 6362QSME2E0D0172H
Driver's Front Airbag Crash Sensor:
Serial number: 63732SME250D2042R
Passenger's Front Airbag Crash Sensor:
Serial number: 63832SME250D2252V
2 Faults Found:
9437211 - Igniter for Driver's Airbag
B1000 1B [137] - Resistance Too High
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 482 km
Date: 2010.01.22
Time: 00:52:12
9437467 - Igniter 2 for Driver's Airbag
B1001 1B [136] - Resistance Too High
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 482 km
Date: 2010.01.22
Time: 00:00:56
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: 8K0-953-568.clb
Part No SW: 8K0 953 568 G HW: 8K0 953 568 G
Component: Lenks.Modul H17 0014
Revision: -------- Serial number: 90372KFN000LA
Coding: 000016
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
Component: E221 - MFL H06 0003
1 Fault Found:
01426 - Controls in Steering Wheel (E221)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 65
Time Indication: 0
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 8T0-920-xxx-17.clb
Part No SW: 8K0 920 981 R HW: 8K0 920 981 R
Component: KOMBIINSTR. H05 0258
Revision: 00100000 Serial number: EJ723FH6C
Coding: 8B1509008300D705020000
Shop #: WSC 06325 000 00000
VCID: 42814E72641F
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: 8T0-907-468.clb
Part No SW: 8T0 907 468 AB HW: 8T0 907 468 H
Component: GW-BEM 5CAN H06 0117
Revision: GB800053 Serial number: 5300G11604856B
Coding: 00C303
Shop #: WSC 06325 000 00000
VCID: 8103017EA199
Part No SW: 8K0 915 181 E HW: 8K0 915 181 E
Component: J367-BDM H07 0170
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels: 8K0-907-163.clb
Part No SW: 8K0 907 163 A HW: 8K0 907 163 A
Component: 4 Wheel Drive H12 0025
Serial number: 001406110001020
ASAM Dataset: EV_AllWheelDiffeQSPCAN 003016
ROD: EV_AllWheelDiffeQSPCAN.rod
VCID: 2E590AC2C087
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3 (R199) Labels: 8T0-035-785.clb
Part No SW: 8T0 035 785 A HW: 8T0 035 785
Component: SG ext.Player H08 0290
Revision: 00000000
Coding: 020302
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 8K0 959 760 D HW: 8K0 959 760 D
Component: MEM-FS H06 0074
Revision: AA000000 Serial number: 00000006311385
Coding: 00581300000000000000
Shop #: WSC 06325 000 00000
VCID: 3B7F339603F5
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: 8K0-959-793.clb
Part No SW: 8T0 959 793 M HW: 8T0 959 793 D
Component: TSG FA H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 53AF7B368B65
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels: 8K0-907-064-46.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001 Serial number: 0152572387
Coding: 0106023A00FA444480B0013200000000
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8K0 959 719 B HW: 8K0 959 719
Component: GTO BF H01 0070
Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
Part No SW: 8K0 959 591 A HW: 8K0 959 591
Component: J245 PS045 H07 0041
No fault code found.
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: None
Part No SW: 8T0 035 223 AR HW: 8T0 035 223 AJ
Component: DSP Prem H19 0320
Revision: 00019001 Serial number: 34816000520502
Coding: 0203010302
Shop #: WSC 06325 000 00000
VCID: 7EF9FA825067
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: 8K0-959-792.clb
Part No SW: 8T0 959 792 M HW: 8T0 959 792 D
Component: TSG BF H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 52A17E32B47F
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540) Labels: 8K0-907-801.clb
Part No SW: 8K0 907 801 H HW: 8K0 907 801 H
Component: EPB Audi B8 H09 0100
Revision: 00000003 Serial number: 10000000814565
Shop #: WSC 00000 000 00000
VCID: 346D18AA2EAB
1 Fault Found:
01321 - Control Module for Airbags (J234)
013 - Check DTC Memory - MIL ON
Freeze Frame:
Fault Status: 11101101
Fault Priority: 4
Fault Frequency: 2
Reset counter: 25
Mileage: 482 km
Time Indication: 0
Date: 2010.01.22
Time: 00:47:59
Freeze Frame:
Voltage: 14.10 V
Count: 80
Speed: 0.0 km/h
Hex Value: 0x0273
Hex Value: 0x0001
Hex Value: 0x1010
-------------------------------------------------------------------------------
Address 55: Xenon Range Labels: 8K0-907-357.clb
Part No: 8K5 907 357 B
Component: Dynamische LWR H02 0010
Revision: 00000001 Serial number:
Coding: 0000004
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels: 8Tx-035-1xx-56.clb
Part No SW: 8T1 035 186 R HW: 8T1 035 186 R
Component: Con3 Sirius H06 0351
Revision: 00000010 Serial number: AUZ5Z6K1604565
Coding: 040300020101850043D9070804
Shop #: WSC 06325 000 00000
VCID: 468952624837
Part No SW: 8T0 919 603 F HW: 8T0 919 603 F
Component: Display
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels: 8K0-959-795.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HL H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels: 8K0-959-794.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HR H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone Labels: 8P0-862-335.lbl
Part No SW: 8T0 862 336 F HW: 8T0 862 336 E
Component: FSE_256x BT H45 0660
Revision: 00000000 Serial number: 00000005230802
Coding: 0010370
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
No fault code found.
End ---------------------------------------------------------------------
On the bright side it appears that the ABS and Parking Brake errors are related to the airbag, so i did not fry any modules. I did insert the key all the way in again every time after battery disconnect.
From what i read faulty wiring can do this, but i did my best using VAG specific tools to repin the new airbag into the S4 connector.
I have full horn, MFC, but get Airbag and Parking Brake Malfunction errors.
HELP!!!
$349 later, here is the spitout, FYI the intermittent contact at radio went away after i stuffed soft wire insulation into the purple retaining rod's tract, no way it could be reinserted without fracture after the brutal pin extractions, i also rechecked the pins for shorts and contact:
Saturday,20,August,2011,13:27:44:39785
VCDS Version: Release 10.6.4
Data version: 20110418
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
Chassis Type: 8T0
Scan: 01 03 05 08 09 15 16 17 19 22 2E 36 42 46 47 52 53 55 56 62
72 77
VIN: WAUDGBFL2CA017467 Mileage: 480km/298miles
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: Malfunction 0010
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: Malfunction 0010
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: Malfunction 0010
16-Steering wheel -- Status: Malfunction 0010
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: Malfunction 0010
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CCBA) Labels: None
Part No SW: 8K0 907 551 D HW: 8K0 907 551 A
Component: 3.0T SIMOS84 H08 0001
Revision: --H08---
Coding: 0104000A180F0128
Shop #: WSC 06324 000 00000
ASAM Dataset: EV_ECM30TFS0218K0907551D 001001
ROD: N/A
VCID: 32611EB2D4BF
No ASAM data for: "EV_ECM30TFS0218K0907551D" (AU48)
No fault code found.
Readiness: 1110 1101
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 8K0-907-379.clb
Part No SW: 8K0 907 379 BJ HW: 8K0 907 379 BJ
Component: ESP8 quattro H04 0060
Revision: -------- Serial number: --------------
Coding: 280D1A
Shop #: WSC 06324 000 00000
VCID: 82010E72A49F
1 Fault Found:
00473 - Control Module for Elect. Park/Hand Brake (J540)
013 - Check DTC Memory
Freeze Frame:
Fault Status: 01101101
Fault Priority: 6
Fault Frequency: 1
Reset counter: 25
Mileage: 482 km
Time Indication: 0
Date: 2010.01.22
Time: 00:45:21
Freeze Frame:
Hex Value: 0x0000
Hex Value: 0x4782
Hex Value: 0x0032
Hex Value: 0x02AE
Hex Value: 0x00FF
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels: 8K0-907-064-05.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001
Coding: 0B0100
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8T0 959 754 AD HW: 8T0 959 754 AD
Component: FBSAUDIB8 IDG H60 0072
Part No SW: 8K0 905 852 D HW: 8K0 905 852 D
Component: J764 ELV MLB H37 0042
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: Redir Fail!
Part No SW: 8T1 820 043 AQ HW: 8T1 820 043 AQ
Component: KLIMA 3 ZONEN H08 0180
Revision: C1000000 Serial number: 01220620110698
Coding: 66002000
Shop #: WSC 06325 000 00000
VCID: 8005047AAA93
1 Fault Found:
01206 - Signal for Duration of Ignition Off Time
008 - Implausible Signal - Intermittent
Freeze Frame:
Fault Status: 00101000
Fault Priority: 7
Fault Frequency: 1
Reset counter: 65
Mileage: 482 km
Time Indication: 0
Date: 2010.01.22
Time: 00:00:55
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 8K0-907-063.clb
Part No SW: 8K0 907 063 P HW: 8K0 907 063 P
Component: BCM1 1.0 H30 0392
Revision: 10030001 Serial number: 00000000952773
Coding: 26001091063CAF212600080300003D0D0F1C92480201016100 0000
Shop #: WSC 06325 000 00000
VCID: 3C7D308A06FB
Part No SW: 8K1 955 119 A HW: 8T1 955 119
Component: WWS 220611 H07 0070
Coding: 00FD11
Part No SW: 8K0 955 559 HW: 8K0 955 559
Component: RLS H04 0003
Coding: 025028
Part No SW: 8K0 941 531 AS HW: 8K0 941 531 AS
Component: E1 - LDS H03 0031
Part No SW: 8K0 907 410 C HW: 8K0 907 410 C
Component: HOMELINK H01 0010
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 8K0-959-655.clb
Part No SW: 8K0 959 655 K HW: 8K0 959 655 K
Component: AirbagVW-AU10 H44 0610
Serial number: 003GLD0NN7CW
Coding: 303937354230303030304A55304C384B3053
Shop #: WSC 06325 000 00000
ASAM Dataset: EV_AirbaECUVWAUDI010 003010
ROD: EV_AirbaECUVWAUDI010_AU48.rod
VCID: 458B556E7531
Seat occupied recognition:
Part No SW: 8K0 959 339 C HW: 8K0 959 339 C
Component: BF-Gewichtss. H02 0040
Serial number: 5810000R11000045GK
Driver's Airbag Crash Sensor:
Serial number: 6334MSME611555512
Passenger Side Airbag Crash Sensor:
Serial number: 6344MSME5F66246CU
Driver's Rear Airbag Crash Sensor:
Serial number: 6352QSME240C2B7AP
Passenger's Rear Airbag Crash Sensor:
Serial number: 6362QSME2E0D0172H
Driver's Front Airbag Crash Sensor:
Serial number: 63732SME250D2042R
Passenger's Front Airbag Crash Sensor:
Serial number: 63832SME250D2252V
2 Faults Found:
9437211 - Igniter for Driver's Airbag
B1000 1B [137] - Resistance Too High
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 482 km
Date: 2010.01.22
Time: 00:52:12
9437467 - Igniter 2 for Driver's Airbag
B1001 1B [136] - Resistance Too High
Freeze Frame:
Fault Status: 00000001
Fault Priority: 2
Fault Frequency: 1
Mileage: 482 km
Date: 2010.01.22
Time: 00:00:56
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: 8K0-953-568.clb
Part No SW: 8K0 953 568 G HW: 8K0 953 568 G
Component: Lenks.Modul H17 0014
Revision: -------- Serial number: 90372KFN000LA
Coding: 000016
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
Component: E221 - MFL H06 0003
1 Fault Found:
01426 - Controls in Steering Wheel (E221)
004 - No Signal/Communication - Intermittent
Freeze Frame:
Fault Status: 00100100
Fault Priority: 2
Fault Frequency: 1
Reset counter: 65
Time Indication: 0
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 8T0-920-xxx-17.clb
Part No SW: 8K0 920 981 R HW: 8K0 920 981 R
Component: KOMBIINSTR. H05 0258
Revision: 00100000 Serial number: EJ723FH6C
Coding: 8B1509008300D705020000
Shop #: WSC 06325 000 00000
VCID: 42814E72641F
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: 8T0-907-468.clb
Part No SW: 8T0 907 468 AB HW: 8T0 907 468 H
Component: GW-BEM 5CAN H06 0117
Revision: GB800053 Serial number: 5300G11604856B
Coding: 00C303
Shop #: WSC 06325 000 00000
VCID: 8103017EA199
Part No SW: 8K0 915 181 E HW: 8K0 915 181 E
Component: J367-BDM H07 0170
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels: 8K0-907-163.clb
Part No SW: 8K0 907 163 A HW: 8K0 907 163 A
Component: 4 Wheel Drive H12 0025
Serial number: 001406110001020
ASAM Dataset: EV_AllWheelDiffeQSPCAN 003016
ROD: EV_AllWheelDiffeQSPCAN.rod
VCID: 2E590AC2C087
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3 (R199) Labels: 8T0-035-785.clb
Part No SW: 8T0 035 785 A HW: 8T0 035 785
Component: SG ext.Player H08 0290
Revision: 00000000
Coding: 020302
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 8K0 959 760 D HW: 8K0 959 760 D
Component: MEM-FS H06 0074
Revision: AA000000 Serial number: 00000006311385
Coding: 00581300000000000000
Shop #: WSC 06325 000 00000
VCID: 3B7F339603F5
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: 8K0-959-793.clb
Part No SW: 8T0 959 793 M HW: 8T0 959 793 D
Component: TSG FA H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 53AF7B368B65
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels: 8K0-907-064-46.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001 Serial number: 0152572387
Coding: 0106023A00FA444480B0013200000000
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8K0 959 719 B HW: 8K0 959 719
Component: GTO BF H01 0070
Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
Part No SW: 8K0 959 591 A HW: 8K0 959 591
Component: J245 PS045 H07 0041
No fault code found.
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: None
Part No SW: 8T0 035 223 AR HW: 8T0 035 223 AJ
Component: DSP Prem H19 0320
Revision: 00019001 Serial number: 34816000520502
Coding: 0203010302
Shop #: WSC 06325 000 00000
VCID: 7EF9FA825067
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: 8K0-959-792.clb
Part No SW: 8T0 959 792 M HW: 8T0 959 792 D
Component: TSG BF H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 52A17E32B47F
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540) Labels: 8K0-907-801.clb
Part No SW: 8K0 907 801 H HW: 8K0 907 801 H
Component: EPB Audi B8 H09 0100
Revision: 00000003 Serial number: 10000000814565
Shop #: WSC 00000 000 00000
VCID: 346D18AA2EAB
1 Fault Found:
01321 - Control Module for Airbags (J234)
013 - Check DTC Memory - MIL ON
Freeze Frame:
Fault Status: 11101101
Fault Priority: 4
Fault Frequency: 2
Reset counter: 25
Mileage: 482 km
Time Indication: 0
Date: 2010.01.22
Time: 00:47:59
Freeze Frame:
Voltage: 14.10 V
Count: 80
Speed: 0.0 km/h
Hex Value: 0x0273
Hex Value: 0x0001
Hex Value: 0x1010
-------------------------------------------------------------------------------
Address 55: Xenon Range Labels: 8K0-907-357.clb
Part No: 8K5 907 357 B
Component: Dynamische LWR H02 0010
Revision: 00000001 Serial number:
Coding: 0000004
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels: 8Tx-035-1xx-56.clb
Part No SW: 8T1 035 186 R HW: 8T1 035 186 R
Component: Con3 Sirius H06 0351
Revision: 00000010 Serial number: AUZ5Z6K1604565
Coding: 040300020101850043D9070804
Shop #: WSC 06325 000 00000
VCID: 468952624837
Part No SW: 8T0 919 603 F HW: 8T0 919 603 F
Component: Display
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels: 8K0-959-795.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HL H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels: 8K0-959-794.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HR H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone Labels: 8P0-862-335.lbl
Part No SW: 8T0 862 336 F HW: 8T0 862 336 E
Component: FSE_256x BT H45 0660
Revision: 00000000 Serial number: 00000005230802
Coding: 0010370
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
No fault code found.
End ---------------------------------------------------------------------
Last edited by Kandiru; 08-20-2011 at 04:20 PM.
08-21-2011, 05:07 PM
#4
AudiWorld Member
Thread Starter
Join Date: Sep 2005
Posts: 142
Likes: 0
Received 0 Likes
on
0 Posts
Eureka!!!
Igniter #1 and 2 at module 15 showed "resistance too high", reading a lot, and out of desperation i took the airbag off again and did a "tuneup" on my pin reinstall job, painstakingly cleaning every pin on the clockspring and MMI connectors using wire insulation dipped in alcohol then used a small drill to enlarge the diameter of the harness openings just a bit, then rubbed inside the females (yum) with alcohol then very little rosin. The pin extraction business is a messy job, even with VAG specific tools, as the micro molex females have a spine to snap into the middle groove and permanently rest there, extraction breaks this off.
I then did reattach, but alas, still codes. Then VCDS with fault deletion, and off went the airbag error, followed by the parking brake, lastly a third sweep killed the ABS error. Now i am left with a misterious sound system error that is enumerated initially but failed to show up in the log,
$344 well deserved to Ross-Tech, knowing also all the little additions that will follow.
Here is the 4th and final spitout, reproducible x2, after the VAG "code laundry":
================================================== =====================
Sunday,21,August,2011,20:34:36:39785
VCDS Version: Release 10.6.4
Data version: 20110418
Chassis Type: 8T0
Scan: 01 03 05 08 09 15 16 17 19 22 2E 36 42 46 47 52 53 55 56 62
72 77
VIN: WAUDGBFL2CA017467 Mileage: 530km/329miles
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CCBA) Labels: None
Part No SW: 8K0 907 551 D HW: 8K0 907 551 A
Component: 3.0T SIMOS84 H08 0001
Revision: --H08---
Coding: 0104000A180F0128
Shop #: WSC 06324 000 00000
ASAM Dataset: EV_ECM30TFS0218K0907551D 001001
ROD: N/A
VCID: 32611EB2D4BF
No ASAM data for: "EV_ECM30TFS0218K0907551D" (AU48)
No fault code found.
Readiness: 1110 1101
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 8K0-907-379.clb
Part No SW: 8K0 907 379 BJ HW: 8K0 907 379 BJ
Component: ESP8 quattro H04 0060
Revision: -------- Serial number: --------------
Coding: 280D1A
Shop #: WSC 06324 000 00000
VCID: 82010E72A49F
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels: 8K0-907-064-05.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001
Coding: 0B0100
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8T0 959 754 AD HW: 8T0 959 754 AD
Component: FBSAUDIB8 IDG H60 0072
Part No SW: 8K0 905 852 D HW: 8K0 905 852 D
Component: J764 ELV MLB H37 0042
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: Redir Fail!
Part No SW: 8T1 820 043 AQ HW: 8T1 820 043 AQ
Component: KLIMA 3 ZONEN H08 0180
Revision: C1000000 Serial number: 01220620110698
Coding: 66002000
Shop #: WSC 06325 000 00000
VCID: 8005047AAA93
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 8K0-907-063.clb
Part No SW: 8K0 907 063 P HW: 8K0 907 063 P
Component: BCM1 1.0 H30 0392
Revision: 10030001 Serial number: 00000000952773
Coding: 26001091063CAF212600080300003D0D0F1C92480201016100 0000
Shop #: WSC 06325 000 00000
VCID: 3C7D308A06FB
Part No SW: 8K1 955 119 A HW: 8T1 955 119
Component: WWS 220611 H07 0070
Coding: 00FD11
Part No SW: 8K0 955 559 HW: 8K0 955 559
Component: RLS H04 0003
Coding: 025028
Part No SW: 8K0 941 531 AS HW: 8K0 941 531 AS
Component: E1 - LDS H03 0031
Part No SW: 8K0 907 410 C HW: 8K0 907 410 C
Component: HOMELINK H01 0010
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 8K0-959-655.clb
Part No SW: 8K0 959 655 K HW: 8K0 959 655 K
Component: AirbagVW-AU10 H44 0610
Serial number: 003GLD0NN7CW
Coding: 303937354230303030304A55304C384B3053
Shop #: WSC 06325 000 00000
ASAM Dataset: EV_AirbaECUVWAUDI010 003010
ROD: EV_AirbaECUVWAUDI010_AU48.rod
VCID: 458B556E7531
Seat occupied recognition:
Part No SW: 8K0 959 339 C HW: 8K0 959 339 C
Component: BF-Gewichtss. H02 0040
Serial number: 5810000R11000045GK
Driver's Airbag Crash Sensor:
Serial number: 6334MSME611555512
Passenger Side Airbag Crash Sensor:
Serial number: 6344MSME5F66246CU
Driver's Rear Airbag Crash Sensor:
Serial number: 6352QSME240C2B7AP
Passenger's Rear Airbag Crash Sensor:
Serial number: 6362QSME2E0D0172H
Driver's Front Airbag Crash Sensor:
Serial number: 63732SME250D2042R
Passenger's Front Airbag Crash Sensor:
Serial number: 63832SME250D2252V
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: 8K0-953-568.clb
Part No SW: 8K0 953 568 G HW: 8K0 953 568 G
Component: Lenks.Modul H17 0014
Revision: -------- Serial number: 90372KFN000LA
Coding: 000016
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
Component: E221 - MFL H06 0003
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 8T0-920-xxx-17.clb
Part No SW: 8K0 920 981 R HW: 8K0 920 981 R
Component: KOMBIINSTR. H05 0258
Revision: 00100000 Serial number: EJ723FH6C
Coding: 8B1509008300D705020000
Shop #: WSC 06325 000 00000
VCID: 42814E72641F
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: 8T0-907-468.clb
Part No SW: 8T0 907 468 AB HW: 8T0 907 468 H
Component: GW-BEM 5CAN H06 0117
Revision: GB800053 Serial number: 5300G11604856B
Coding: 00C303
Shop #: WSC 06325 000 00000
VCID: 8103017EA199
Part No SW: 8K0 915 181 E HW: 8K0 915 181 E
Component: J367-BDM H07 0170
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels: 8K0-907-163.clb
Part No SW: 8K0 907 163 A HW: 8K0 907 163 A
Component: 4 Wheel Drive H12 0025
Serial number: 001406110001020
ASAM Dataset: EV_AllWheelDiffeQSPCAN 003016
ROD: EV_AllWheelDiffeQSPCAN.rod
VCID: 2E590AC2C087
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3 (R199) Labels: 8T0-035-785.clb
Part No SW: 8T0 035 785 A HW: 8T0 035 785
Component: SG ext.Player H08 0290
Revision: 00000000
Coding: 020302
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 8K0 959 760 D HW: 8K0 959 760 D
Component: MEM-FS H06 0074
Revision: AA000000 Serial number: 00000006311385
Coding: 00581300000000000000
Shop #: WSC 06325 000 00000
VCID: 3B7F339603F5
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: 8K0-959-793.clb
Part No SW: 8T0 959 793 M HW: 8T0 959 793 D
Component: TSG FA H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 53AF7B368B65
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels: 8K0-907-064-46.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001 Serial number: 0152572387
Coding: 0106023A00FA444480B0013200000000
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8K0 959 719 B HW: 8K0 959 719
Component: GTO BF H01 0070
Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
Part No SW: 8K0 959 591 A HW: 8K0 959 591
Component: J245 PS045 H07 0041
No fault code found.
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: None
Part No SW: 8T0 035 223 AR HW: 8T0 035 223 AJ
Component: DSP Prem H19 0320
Revision: 00019001 Serial number: 34816000520502
Coding: 0203010302
Shop #: WSC 06325 000 00000
VCID: 7EF9FA825067
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: 8K0-959-792.clb
Part No SW: 8T0 959 792 M HW: 8T0 959 792 D
Component: TSG BF H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 52A17E32B47F
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540) Labels: 8K0-907-801.clb
Part No SW: 8K0 907 801 H HW: 8K0 907 801 H
Component: EPB Audi B8 H09 0100
Revision: 00000003 Serial number: 10000000814565
Shop #: WSC 00000 000 00000
VCID: 346D18AA2EAB
No fault code found.
-------------------------------------------------------------------------------
Address 55: Xenon Range Labels: 8K0-907-357.clb
Part No: 8K5 907 357 B
Component: Dynamische LWR H02 0010
Revision: 00000001 Serial number:
Coding: 0000004
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels: 8Tx-035-1xx-56.clb
Part No SW: 8T1 035 186 R HW: 8T1 035 186 R
Component: Con3 Sirius H06 0351
Revision: 00000010 Serial number: AUZ5Z6K1604565
Coding: 040300020101850043D9070804
Shop #: WSC 06325 000 00000
VCID: 468952624837
Part No SW: 8T0 919 603 F HW: 8T0 919 603 F
Component: Display
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels: 8K0-959-795.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HL H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels: 8K0-959-794.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HR H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone Labels: 8P0-862-335.lbl
Part No SW: 8T0 862 336 F HW: 8T0 862 336 E
Component: FSE_256x BT H45 0660
Revision: 00000000 Serial number: 00000005230802
Coding: 0010370
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
No fault code found.
End ---------------------------------------------------------------------
Igniter #1 and 2 at module 15 showed "resistance too high", reading a lot, and out of desperation i took the airbag off again and did a "tuneup" on my pin reinstall job, painstakingly cleaning every pin on the clockspring and MMI connectors using wire insulation dipped in alcohol
then used a small drill to enlarge the diameter of the harness openings just a bit, then rubbed inside the females (yum) with alcohol then very little rosin. The pin extraction business is a messy job, even with VAG specific tools, as the micro molex females have a spine to snap into the middle groove and permanently rest there, extraction breaks this off.I then did reattach, but alas, still codes. Then VCDS with fault deletion, and off went the airbag error, followed by the parking brake, lastly a third sweep killed the ABS error. Now i am left with a misterious sound system error that is enumerated initially but failed to show up in the log,
$344 well deserved to Ross-Tech, knowing also all the little additions that will follow.
Here is the 4th and final spitout, reproducible x2, after the VAG "code laundry":
================================================== =====================
Sunday,21,August,2011,20:34:36:39785
VCDS Version: Release 10.6.4
Data version: 20110418
Chassis Type: 8T0
Scan: 01 03 05 08 09 15 16 17 19 22 2E 36 42 46 47 52 53 55 56 62
72 77
VIN: WAUDGBFL2CA017467 Mileage: 530km/329miles
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 01: Engine (J623-CCBA) Labels: None
Part No SW: 8K0 907 551 D HW: 8K0 907 551 A
Component: 3.0T SIMOS84 H08 0001
Revision: --H08---
Coding: 0104000A180F0128
Shop #: WSC 06324 000 00000
ASAM Dataset: EV_ECM30TFS0218K0907551D 001001
ROD: N/A
VCID: 32611EB2D4BF
No ASAM data for: "EV_ECM30TFS0218K0907551D" (AU48)
No fault code found.
Readiness: 1110 1101
-------------------------------------------------------------------------------
Address 03: ABS Brakes (J104) Labels: 8K0-907-379.clb
Part No SW: 8K0 907 379 BJ HW: 8K0 907 379 BJ
Component: ESP8 quattro H04 0060
Revision: -------- Serial number: --------------
Coding: 280D1A
Shop #: WSC 06324 000 00000
VCID: 82010E72A49F
No fault code found.
-------------------------------------------------------------------------------
Address 05: Acc/Start Auth. (J393) Labels: 8K0-907-064-05.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001
Coding: 0B0100
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8T0 959 754 AD HW: 8T0 959 754 AD
Component: FBSAUDIB8 IDG H60 0072
Part No SW: 8K0 905 852 D HW: 8K0 905 852 D
Component: J764 ELV MLB H37 0042
No fault code found.
-------------------------------------------------------------------------------
Address 08: Auto HVAC (J255) Labels: Redir Fail!
Part No SW: 8T1 820 043 AQ HW: 8T1 820 043 AQ
Component: KLIMA 3 ZONEN H08 0180
Revision: C1000000 Serial number: 01220620110698
Coding: 66002000
Shop #: WSC 06325 000 00000
VCID: 8005047AAA93
No fault code found.
-------------------------------------------------------------------------------
Address 09: Cent. Elect. (J519) Labels: 8K0-907-063.clb
Part No SW: 8K0 907 063 P HW: 8K0 907 063 P
Component: BCM1 1.0 H30 0392
Revision: 10030001 Serial number: 00000000952773
Coding: 26001091063CAF212600080300003D0D0F1C92480201016100 0000
Shop #: WSC 06325 000 00000
VCID: 3C7D308A06FB
Part No SW: 8K1 955 119 A HW: 8T1 955 119
Component: WWS 220611 H07 0070
Coding: 00FD11
Part No SW: 8K0 955 559 HW: 8K0 955 559
Component: RLS H04 0003
Coding: 025028
Part No SW: 8K0 941 531 AS HW: 8K0 941 531 AS
Component: E1 - LDS H03 0031
Part No SW: 8K0 907 410 C HW: 8K0 907 410 C
Component: HOMELINK H01 0010
No fault code found.
-------------------------------------------------------------------------------
Address 15: Airbags (J234) Labels: 8K0-959-655.clb
Part No SW: 8K0 959 655 K HW: 8K0 959 655 K
Component: AirbagVW-AU10 H44 0610
Serial number: 003GLD0NN7CW
Coding: 303937354230303030304A55304C384B3053
Shop #: WSC 06325 000 00000
ASAM Dataset: EV_AirbaECUVWAUDI010 003010
ROD: EV_AirbaECUVWAUDI010_AU48.rod
VCID: 458B556E7531
Seat occupied recognition:
Part No SW: 8K0 959 339 C HW: 8K0 959 339 C
Component: BF-Gewichtss. H02 0040
Serial number: 5810000R11000045GK
Driver's Airbag Crash Sensor:
Serial number: 6334MSME611555512
Passenger Side Airbag Crash Sensor:
Serial number: 6344MSME5F66246CU
Driver's Rear Airbag Crash Sensor:
Serial number: 6352QSME240C2B7AP
Passenger's Rear Airbag Crash Sensor:
Serial number: 6362QSME2E0D0172H
Driver's Front Airbag Crash Sensor:
Serial number: 63732SME250D2042R
Passenger's Front Airbag Crash Sensor:
Serial number: 63832SME250D2252V
No fault code found.
-------------------------------------------------------------------------------
Address 16: Steering wheel (J527) Labels: 8K0-953-568.clb
Part No SW: 8K0 953 568 G HW: 8K0 953 568 G
Component: Lenks.Modul H17 0014
Revision: -------- Serial number: 90372KFN000LA
Coding: 000016
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
Component: E221 - MFL H06 0003
No fault code found.
-------------------------------------------------------------------------------
Address 17: Instruments (J285) Labels: 8T0-920-xxx-17.clb
Part No SW: 8K0 920 981 R HW: 8K0 920 981 R
Component: KOMBIINSTR. H05 0258
Revision: 00100000 Serial number: EJ723FH6C
Coding: 8B1509008300D705020000
Shop #: WSC 06325 000 00000
VCID: 42814E72641F
No fault code found.
-------------------------------------------------------------------------------
Address 19: CAN Gateway (J533) Labels: 8T0-907-468.clb
Part No SW: 8T0 907 468 AB HW: 8T0 907 468 H
Component: GW-BEM 5CAN H06 0117
Revision: GB800053 Serial number: 5300G11604856B
Coding: 00C303
Shop #: WSC 06325 000 00000
VCID: 8103017EA199
Part No SW: 8K0 915 181 E HW: 8K0 915 181 E
Component: J367-BDM H07 0170
No fault code found.
-------------------------------------------------------------------------------
Address 22: AWD (J492) Labels: 8K0-907-163.clb
Part No SW: 8K0 907 163 A HW: 8K0 907 163 A
Component: 4 Wheel Drive H12 0025
Serial number: 001406110001020
ASAM Dataset: EV_AllWheelDiffeQSPCAN 003016
ROD: EV_AllWheelDiffeQSPCAN.rod
VCID: 2E590AC2C087
No fault code found.
-------------------------------------------------------------------------------
Address 2E: Media Player 3 (R199) Labels: 8T0-035-785.clb
Part No SW: 8T0 035 785 A HW: 8T0 035 785
Component: SG ext.Player H08 0290
Revision: 00000000
Coding: 020302
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 36: Seat Mem. Drvr (J136) Labels: None
Part No SW: 8K0 959 760 D HW: 8K0 959 760 D
Component: MEM-FS H06 0074
Revision: AA000000 Serial number: 00000006311385
Coding: 00581300000000000000
Shop #: WSC 06325 000 00000
VCID: 3B7F339603F5
No fault code found.
-------------------------------------------------------------------------------
Address 42: Door Elect, Driver (J386) Labels: 8K0-959-793.clb
Part No SW: 8T0 959 793 M HW: 8T0 959 793 D
Component: TSG FA H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 53AF7B368B65
No fault code found.
-------------------------------------------------------------------------------
Address 46: Central Conv. (J393) Labels: 8K0-907-064-46.clb
Part No SW: 8K0 907 064 CF HW: 8K0 907 064 CF
Component: BCM2 2.0 H05 0435
Revision: 00002001 Serial number: 0152572387
Coding: 0106023A00FA444480B0013200000000
Shop #: WSC 06325 000 00000
VCID: 76E9E2A27857
Part No SW: 8K0 959 719 B HW: 8K0 959 719
Component: GTO BF H01 0070
Part No: 1K0 951 605 C
Component: LIN BACKUP HO H05 1501
Part No SW: 8K0 959 591 A HW: 8K0 959 591
Component: J245 PS045 H07 0041
No fault code found.
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: None
Part No SW: 8T0 035 223 AR HW: 8T0 035 223 AJ
Component: DSP Prem H19 0320
Revision: 00019001 Serial number: 34816000520502
Coding: 0203010302
Shop #: WSC 06325 000 00000
VCID: 7EF9FA825067
No fault code found.
-------------------------------------------------------------------------------
Address 52: Door Elect, Pass. (J387) Labels: 8K0-959-792.clb
Part No SW: 8T0 959 792 M HW: 8T0 959 792 D
Component: TSG BF H08 1501
Revision: -------- Serial number: --------------
Coding: 011C03204E00410001
Shop #: WSC 06325 000 00000
VCID: 52A17E32B47F
No fault code found.
-------------------------------------------------------------------------------
Address 53: Parking Brake (J540) Labels: 8K0-907-801.clb
Part No SW: 8K0 907 801 H HW: 8K0 907 801 H
Component: EPB Audi B8 H09 0100
Revision: 00000003 Serial number: 10000000814565
Shop #: WSC 00000 000 00000
VCID: 346D18AA2EAB
No fault code found.
-------------------------------------------------------------------------------
Address 55: Xenon Range Labels: 8K0-907-357.clb
Part No: 8K5 907 357 B
Component: Dynamische LWR H02 0010
Revision: 00000001 Serial number:
Coding: 0000004
Shop #: WSC 06325 000 00000
VCID: 3973299E09C9
No fault code found.
-------------------------------------------------------------------------------
Address 56: Radio (J503) Labels: 8Tx-035-1xx-56.clb
Part No SW: 8T1 035 186 R HW: 8T1 035 186 R
Component: Con3 Sirius H06 0351
Revision: 00000010 Serial number: AUZ5Z6K1604565
Coding: 040300020101850043D9070804
Shop #: WSC 06325 000 00000
VCID: 468952624837
Part No SW: 8T0 919 603 F HW: 8T0 919 603 F
Component: Display
No fault code found.
-------------------------------------------------------------------------------
Address 62: Door, Rear Left (J388) Labels: 8K0-959-795.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HL H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 72: Door, Rear Right (J389) Labels: 8K0-959-794.clb
Part No SW: 8T0 959 795 N HW: 8T0 959 795 B
Component: TSG HR H06 1501
Revision: -------- Serial number: --------------
Coding: 010C03204000210001
Shop #: WSC 06325 000 00000
VCID: 56A982229897
No fault code found.
-------------------------------------------------------------------------------
Address 77: Telephone Labels: 8P0-862-335.lbl
Part No SW: 8T0 862 336 F HW: 8T0 862 336 E
Component: FSE_256x BT H45 0660
Revision: 00000000 Serial number: 00000005230802
Coding: 0010370
Shop #: WSC 06325 000 00000
VCID: 3E793A8210E7
No fault code found.
End ---------------------------------------------------------------------
08-21-2011, 06:55 PM
#5
AudiWorld Member
Join Date: Sep 2009
Posts: 196
Likes: 0
Received 0 Likes
on
0 Posts
Now i am left with a misterious sound system error that is enumerated initially but failed to show up in the log,
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: None
Part No SW: 8T0 035 223 AR HW: 8T0 035 223 AJ
Component: DSP Prem H19 0320
Revision: 00019001 Serial number: 34816000520502
Coding: 0203010302
Shop #: WSC 06325 000 00000
VCID: 7EF9FA825067
No fault code found.
01-Engine -- Status: OK 0000
03-ABS Brakes -- Status: OK 0000
04-Steering Angle -- Status: OK 0000
05-Acc/Start Auth. -- Status: OK 0000
08-Auto HVAC -- Status: OK 0000
09-Cent. Elect. -- Status: OK 0000
15-Airbags -- Status: OK 0000
16-Steering wheel -- Status: OK 0000
17-Instruments -- Status: OK 0000
19-CAN Gateway -- Status: OK 0000
22-AWD -- Status: OK 0000
2E-Media Player 3 -- Status: OK 0000
36-Seat Mem. Drvr -- Status: OK 0000
42-Door Elect, Driver -- Status: OK 0000
46-Central Conv. -- Status: OK 0000
47-Sound System -- Status: Malfunction 0010
52-Door Elect, Pass. -- Status: OK 0000
53-Parking Brake -- Status: OK 0000
55-Xenon Range -- Status: OK 0000
56-Radio -- Status: OK 0000
62-Door, Rear Left -- Status: OK 0000
72-Door, Rear Right -- Status: OK 0000
77-Telephone -- Status: OK 0000
-------------------------------------------------------------------------------
Address 47: Sound System (J525) Labels: None
Part No SW: 8T0 035 223 AR HW: 8T0 035 223 AJ
Component: DSP Prem H19 0320
Revision: 00019001 Serial number: 34816000520502
Coding: 0203010302
Shop #: WSC 06325 000 00000
VCID: 7EF9FA825067
No fault code found.
The fault listed in the 19-CAN Gateway installation list may be a fluke. Try the [Clear All DTCs] feature on the Auto-Scan screen followed by a key cycle, and possibly operating the radio/amp, and see if it returns. The Address 47-Sound System itself would have a fault code if something was actually wrong.
Thread
Thread Starter
Forum
Replies
Last Post
tipo158
A4 (B5 Platform) Discussion
5
09-25-2006 09:43 PM
i8pancit
A4 (B6 Platform) Discussion
3
04-29-2004 09:42 PM
