'01 Audi TT - Rattle and running hot
#1
'01 Audi TT - Rattle and running hot
Looking for some advice. My TT has 80K miles and I have put 60K of those miles on myself.
I have two issues I was hoping someone could advise me on:
1) It is rattling when cold (and even sometimes when warm) and I think, based on researching this forum, that it might be the cam tensioner.
2) Recently the temp gauge has been going past half way after a spirited drive when I come to a stop. It never used to do that. I did the 49C test and can see temps getting to 104c then the fan kicks on (I think) and it starts to cool.
Troubleshooting Steps Thus Far:
Oil Pressure appears normal - I am getting 80PSI cold idle, 25PSI warm idle, 50PSI warm 2k RPM, and 70PSI warn 3k RPM.
I changed the oil (Motul 8100 5-W40) with quality large oil filter. Previously I had been running Castrol Syntec 5-40. The Motul has reduced the rattle, but it's not totally gone.
I have attached some pics of my cams and valve cover. I don't know how to tell if my tensioner is bad. The cam chain is very tight.
Any advice would be greatly appreciated.
Thanks, Phil
I have two issues I was hoping someone could advise me on:
1) It is rattling when cold (and even sometimes when warm) and I think, based on researching this forum, that it might be the cam tensioner.
2) Recently the temp gauge has been going past half way after a spirited drive when I come to a stop. It never used to do that. I did the 49C test and can see temps getting to 104c then the fan kicks on (I think) and it starts to cool.
Troubleshooting Steps Thus Far:
Oil Pressure appears normal - I am getting 80PSI cold idle, 25PSI warm idle, 50PSI warm 2k RPM, and 70PSI warn 3k RPM.
I changed the oil (Motul 8100 5-W40) with quality large oil filter. Previously I had been running Castrol Syntec 5-40. The Motul has reduced the rattle, but it's not totally gone.
I have attached some pics of my cams and valve cover. I don't know how to tell if my tensioner is bad. The cam chain is very tight.
Any advice would be greatly appreciated.
Thanks, Phil
Thread
Thread Starter
Forum
Replies
Last Post
01northernS4
S4 / RS4 (B5 Platform) Discussion
35
03-05-2007 05:02 PM
dolbnyc
A4 (B6 Platform) Discussion
3
02-04-2007 09:51 AM