2005 A6 3.2 reconstruction
I am in the process of reconstructing a 2005 3.2 A6 that was hit in the front. I replaced the front clip and engine with a 2007 3.2 with 7 miles on it. Finally got the car running after dealer reprogrammed the immobilizer. The car runs and seems to drive fine, however I am getting the following error codes. Can anyone help to point me in the right direction as to what might be causing the problems. I know some of the issues such as the airbag and digital radio errors. But my main concerns are the trans code and engine intake manifold tuning valve code. Any suggestions would be greatly appreciated!
Thanks! 00-Steering Angle Sensor -- Status: OK 0000 01-Engine -- Status: Malfunction 0010 02-Auto Trans -- Status: Malfunction 0010 03-ABS Brakes -- Status: OK 0000 05-Acc/Start Auth. -- Status: OK 0000 07-Control Head -- Status: OK 0000 08-Auto HVAC -- Status: Malfunction 0010 09-Cent. Elect. -- Status: Malfunction 0010 0E-Media Player 1 -- Status: OK 0000 0F-Digital Radio -- Status: Cannot be reached 1100 15-Airbags -- Status: Malfunction 0010 16-Steering wheel -- Status: Malfunction 0010 17-Instruments -- Status: Malfunction 0010 19-CAN Gateway -- Status: Malfunction 0010 25-Immobilizer -- Status: OK 0000 36-Seat Mem. Drvr -- Status: Malfunction 0010 42-Door Elect, Driver -- Status: OK 0000 46-Central Conv. -- Status: OK 0000 47-Sound System -- Status: Malfunction 0010 4F-Centr. Electr. II -- Status: OK 0000 52-Door Elect, Pass. -- Status: OK 0000 53-Parking Brake -- Status: OK 0000 55-Xenon Range -- Status: Malfunction 0010 56-Radio -- Status: OK 0000 61-Battery Regul. -- Status: OK 0000 62-Door,Rear Left -- Status: OK 0000 72-Door, Rear Right -- Status: OK 0000 77-Telephone -- Status: OK 0000 ------------------------------------------------------------------------------- Address 01: Engine Labels: None Part No SW: 4F2 910 559 C HW: 4F1 907 559 E Component: 3.2l V6 FSI 0020 Coding: 01050109190F0120 Shop #: WSC 02325 3 Faults Found: 008304 - Intake Manifold Tuning Valve (Bank 1): Stuck Open P2070 - 006 - Short to Plus Freeze Frame: Fault Status: 00100001 Fault Priority: 2 Fault Frequency: 18 Reset counter: 40 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:13:37 Freeze Frame: RPM: 1280 /min Mass Air / Rev.: 179.8 mg/str Temperature: 1.5°C Idle Absolute Pres.: 404.3 mbar Speed: 0.0 km/h 008198 - Intake Manifold Flap; Bank 1: Stuck Closed P2006 - 006 - Short to Plus - MIL ON Freeze Frame: Fault Status: 10100001 Fault Priority: 4 Fault Frequency: 2 Reset counter: 40 Mileage: 60577 km Time Indication: 0 Date: 2008.02.06 Time: 16:38:11 Freeze Frame: RPM: 2880 /min Mass Air / Rev.: 555.9 mg/str Temperature: 93.0°C Part Throttle Voltage: 1.300 V Speed: 64.0 km/h 008199 - Intake Manifold Flap; Bank 2: Stuck Closed P2007 - 006 - Short to Plus - MIL ON Freeze Frame: Fault Status: 10100001 Fault Priority: 4 Fault Frequency: 2 Reset counter: 40 Mileage: 60577 km Time Indication: 0 Date: 2008.02.06 Time: 16:38:11 Freeze Frame: RPM: 2880 /min Mass Air / Rev.: 555.9 mg/str Temperature: 93.0°C Part Throttle Voltage: 1.320 V Speed: 64.0 km/h Readiness: 0010 0101 ------------------------------------------------------------------------------- Address 02: Auto Trans Labels: None Part No SW: 4F1 910 156 H HW: 09L 927 156 Component: AG6 09L 3.2 FSI USA 0020 Coding: 0001002 Shop #: WSC 02325 2 Faults Found: 18162 - Tiptronic Up Switch (F189): Open or Short to Plus P1754 - 000 - - Freeze Frame: Fault Status: 01100000 Fault Priority: 0 Fault Frequency: 1 Reset counter: 40 Mileage: 60576 km Time Indication: 0 Date: 2008.01.13 Time: 14:22:53 Freeze Frame: RPM: 800 /min RPM: 576 /min RPM: 0 /min (no units): 23.0 (no units): 35.0 Temperature: 5.0°C T.B. Angle: 0.0° 18163 - Tiptronic Down Switch (F189): Open or Short to Plus P1755 - 000 - - Freeze Frame: Fault Status: 01100000 Fault Priority: 0 Fault Frequency: 1 Reset counter: 40 Mileage: 60576 km Time Indication: 0 Date: 2008.01.13 Time: 14:22:53 ------------------------------------------------------------------------------- Address 03: ABS Brakes Labels: 4F0-910-517.LBL Part No SW: 4F0 910 517 E HW: 4F0 614 517 A Component: ESP8 quattro H03 0010 Coding: 0004511 Shop #: WSC 02325 No fault code found. ------------------------------------------------------------------------------- Address 05: Acc/Start Auth. Labels: 4F0-910-852.LBL Part No SW: 4F0 910 852 HW: 4F0 905 852 B Component: FBSAUDIC6 ELV H30 0130 Coding: 0000011 Shop #: WSC 02323 Part No: 4F0 910 131 J Component: FBSAUDIC6 EZS H43 0070 Part No: 4F0 910 220 A Component: FBSAUDIC6 IDG H35 0040 No fault code found. ------------------------------------------------------------------------------- Address 07: Control Head Labels: 4F0-910-7xx-07-H.LBL Part No SW: 4F0 910 729 B HW: 4E0 035 729 Component: Interfacebox H43 0750 Coding: 0000003 Shop #: WSC 02335 Part No: 4F0 910 609 Component: Bedienteil MMIC6H07 0870 No fault code found. ------------------------------------------------------------------------------- Address 08: Auto HVAC Labels: 4F0-910-043.LBL Part No SW: 4F0 910 043 HW: 4F1 820 043 J Component: KLIMABETAETIGUNGH11 0110 Coding: 0524326 Shop #: WSC 02325 1 Fault Found: 00256 - A/C Pressure/Temperature Sensor (G395) 002 - Lower Limit Exceeded - Intermittent Freeze Frame: Fault Status: 00110010 Fault Priority: 3 Fault Frequency: 3 Reset counter: 140 Mileage: 60576 km Time Indication: 0 Date: 2008.01.21 Time: 17:01:27 ------------------------------------------------------------------------------- Address 09: Cent. Elect. Labels: 4F0-910-279.LBL Part No SW: 4F0 910 279 HW: 4F0 907 279 Component: ILM Fahrer H14 0080 Coding: 0013123 Shop #: WSC 02335 Part No: 4F1 910 113 Component: Wischer AudiC6 H05 0150 Coding: 00062736 Shop #: WSC 02335 Part No: 4E0 910 557 Component: REGENLICHTSENSORH10 0050 Coding: 00141886 Shop #: WSC 02335 5 Faults Found: 01493 - Bulb for Blinkers; Front Left (M5) 011 - Open Circuit - Intermittent Freeze Frame: Fault Status: 00101011 Fault Priority: 2 Fault Frequency: 7 Reset counter: 135 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:10:00 01497 - Bulb for Blinkers; Front Right (M7) 011 - Open Circuit - Intermittent Freeze Frame: Fault Status: 00101011 Fault Priority: 2 Fault Frequency: 6 Reset counter: 135 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:10:00 02746 - Bulb for Daytime Running Light; Right 011 - Open Circuit - Intermittent Freeze Frame: Fault Status: 00101011 Fault Priority: 2 Fault Frequency: 6 Reset counter: 135 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:00 01494 - Bulb for Parking Lamps; Left (M1) 011 - Open Circuit - Intermittent Freeze Frame: Fault Status: 00101011 Fault Priority: 2 Fault Frequency: 7 Reset counter: 135 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:10:00 01498 - Bulb for Parking Lamps; Right (M3) 011 - Open Circuit - Intermittent Freeze Frame: Fault Status: 00101011 Fault Priority: 2 Fault Frequency: 6 Reset counter: 135 Mileage: 60576 km Time Indication: 0 Date: 2008.01.07 Time: 19:10:00 ------------------------------------------------------------------------------- Address 0E: Media Player 1 Labels: 4E0-910-111.LBL Part No SW: 4E0 910 111 D HW: 4E0 035 111 A Component: CD-Changer H44 0340 No fault code found. ------------------------------------------------------------------------------- Address 0F: Digital Radio Cannot be reached ------------------------------------------------------------------------------- Address 15: Airbags Labels: 4F0-910-655.LBL Part No SW: 4F0 910 655 B HW: 4F0 959 655 A Component: 56 AIRBAG AUDI8RH28 0310 Coding: 0013622 Shop #: WSC 06158 Part No: 4F0 910 339 Component: BF-Gewichtsens. 002 0040 6 Faults Found: 00588 - Airbag Igniter; Driver Side (N95) 001 - Upper Limit Exceeded - MIL ON 01590 - Igniter for Battery Disconnect (N253) 001 - Upper Limit Exceeded - MIL ON 00654 - Seat Belt Tensioner Igniter; Driver Side (N153) 001 - Upper Limit Exceeded - MIL ON 01587 - Igniter 2 for Airbag; Drivers Side (N250) 001 - Upper Limit Exceeded - MIL ON 01738 - Crash Sensor for Front Airbag; Drivers Side (G283) 014 - Defective - MIL ON 01739 - Crash Sensor for Front Airbag; Pass. Side (G284) 014 - Defective - MIL ON ------------------------------------------------------------------------------- Address 16: Steering wheel Labels: 4F0-910-549.LBL Part No SW: 4F0 910 549 HW: 4F0 953 549 A Component: Lenksäulenmodul H07 0230 Coding: 0002041 Shop #: WSC 02323 Part No: XXXXXXXXXXX Component: Lenkradmodul H05 0080 1 Fault Found: 01426 - Controls in Steering Wheel (E221) 004 - No Signal/Communication - Intermittent Freeze Frame: Fault Status: 00100100 Fault Priority: 3 Fault Frequency: 2 Reset counter: 139 Mileage: 60576 km Time Indication: 0 Date: 2008.01.18 Time: 16:13:23 ------------------------------------------------------------------------------- Address 17: Instruments Labels: 4F0-910-xxx-17.LBL Part No SW: 4F0 910 900 A HW: 4F0 920 950 M Component: KOMBIINSTR. M73 H09 0660 Coding: 0065263 Shop #: WSC 06158 1 Fault Found: 00779 - Outside Air Temp Sensor (G17) 010 - Open or Short to Plus Freeze Frame: Fault Status: 01101010 Fault Priority: 7 Fault Frequency: 1 Reset counter: 93 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:17 ------------------------------------------------------------------------------- Address 19: CAN Gateway Labels: 4F0-910-468.LBL Part No SW: 4F0 910 468 A HW: 4F0 907 468 B Component: Gateway H09 0030 Coding: 6CFE73CC1B1904 Shop #: WSC 02325 2 Faults Found: 00470 - Combination comfort Databus in Single Wire 011 - Open Circuit Freeze Frame: Fault Status: 01101011 Fault Priority: 3 Fault Frequency: 1 Reset counter: 93 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:17 02230 - Digital Radio (DAB) (R147) 004 - No Signal/Communication Freeze Frame: Fault Status: 01100100 Fault Priority: 3 Fault Frequency: 1 Reset counter: 93 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:09:17 ------------------------------------------------------------------------------- Address 25: Immobilizer Cannot be reached ------------------------------------------------------------------------------- Address 36: Seat Mem. Drvr Labels: None Part No SW: 4F0 910 760 HW: 4F0 959 760 Component: Sitzmemory FS H04 0050 Coding: 0082946 Shop #: WSC 02325 5 Faults Found: 01447 - Sensor for Driver Seat; Height Adjust (G231) 005 - No or Incorrect Basic Setting / Adaptation Freeze Frame: Fault Status: 01100101 Fault Priority: 4 Fault Frequency: 1 Reset counter: 100 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:15 01448 - Sensor for Driver Seat; Tilt Adjust (G232) 005 - No or Incorrect Basic Setting / Adaptation - Intermittent Freeze Frame: Fault Status: 00100101 Fault Priority: 4 Fault Frequency: 1 Reset counter: 136 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:15 01446 - Sensor for Driver Seat; Seatback Adjust (G230) 005 - No or Incorrect Basic Setting / Adaptation Freeze Frame: Fault Status: 01100101 Fault Priority: 4 Fault Frequency: 1 Reset counter: 100 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:15 01445 - Sensor for Driver Seat Fore/Aft (G227) 005 - No or Incorrect Basic Setting / Adaptation Freeze Frame: Fault Status: 01100101 Fault Priority: 4 Fault Frequency: 1 Reset counter: 100 Mileage: 60576 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:15 00003 - Control Module 005 - No or Incorrect Basic Setting / Adaptation Freeze Frame: Fault Status: 01100101 Fault Priority: 2 Fault Frequency: 1 Reset counter: 100 Mileage: 0 km Time Indication: 0 Date: 2004.01.01 Time: 00:00:00 ------------------------------------------------------------------------------- Address 42: Door Elect, Driver Labels: 4F0-910-793-42.LBL Part No SW: 4F0 910 793 B HW: 4F0 959 793 B Component: TSG FA H10 0020 Coding: 0035563 Shop #: WSC 02327 No fault code found. ------------------------------------------------------------------------------- Address 46: Central Conv. Labels: 4F0-910-289.LBL Part No SW: 4F0 910 289 E HW: 4F0 907 289 E Component: Komfortgeraet H14 0090 Coding: 0423997 Shop #: WSC 02335 Part No: 1K0 951 605 C Component: LIN BACKUP HORN H02 1301 No fault code found. ------------------------------------------------------------------------------- Address 47: Sound System Labels: 4Fx-910-223-BO.LBL Part No SW: 4F5 910 223 B HW: 4F5 035 223 C Component: DSP-High C6 H14 0220 Coding: 0000016 Shop #: WSC 02325 2 Faults Found: 01044 - Control Module Incorrectly Coded 000 - - - Intermittent Freeze Frame: Fault Status: 00100000 Fault Priority: 7 Fault Frequency: 1 Reset counter: 136 Mileage: 60576 km Time Indication: 0 Date: 2008.01.25 Time: 00:05:09 01316 - ABS Control Module 004 - No Signal/Communication - Intermittent Freeze Frame: Fault Status: 00100100 Fault Priority: 6 Fault Frequency: 1 Reset counter: 97 Time Indication: 0 ------------------------------------------------------------------------------- Address 4F: Centr. Electr. II Labels: 4F0-910-280.LBL Part No SW: 4F0 910 280 HW: 4F0 907 280 A Component: ILM Beifahrer H09 0050 Coding: 0001114 Shop #: WSC 02323 No fault code found. ------------------------------------------------------------------------------- Address 52: Door Elect, Pass. Labels: 4F0-910-793-52.LBL Part No SW: 4F0 910 793 B HW: 4F0 959 792 B Component: TSG BF H10 0020 Coding: 0035563 Shop #: WSC 02327 No fault code found. ------------------------------------------------------------------------------- Address 53: Parking Brake Labels: 4F0-910-801.LBL Part No SW: 4F0 910 801 HW: 4F0 907 801 Component: EPB C43HC002 H03 0020 Coding: 0005022 Shop #: WSC 02334 No fault code found. ------------------------------------------------------------------------------- Address 55: Xenon Range Labels: 4F0-910-357.LBL Part No SW: 4F0 910 357 A HW: 4F0 907 357 A Component: AFS 1 H03 0010 Coding: 0000016 Shop #: WSC 02325 Part No: 4F0 941 329 A Component: AFS-Modul links H05 0010 Part No: 4F0 941 329 A Component: AFS-Modul rechtsH05 0010 2 Faults Found: 02071 - Local Databus 004 - No Signal/Communication - Intermittent Freeze Frame: Fault Status: 00100100 Fault Priority: 2 Fault Frequency: 1 Reset counter: 40 Mileage: 60584 km Time Indication: 0 Date: 2008.01.06 Time: 17:08:19 02234 - Right Headlight Power Output Stage (J668) 004 - No Signal/Communication - Intermittent Freeze Frame: Fault Status: 00100100 Fault Priority: 2 Fault Frequency: 8 Reset counter: 40 Mileage: 60584 km Time Indication: 0 Date: 2008.01.07 Time: 19:10:54 ------------------------------------------------------------------------------- Address 56: Radio Labels: 4E0-910-541.LBL Part No SW: 4E0 910 541 C HW: 4F0 035 541 Component: TUNER EU/US/RDW H41 0290 Coding: 0000002 Shop #: WSC 02325 No fault code found. ------------------------------------------------------------------------------- Address 61: Battery Regul. Labels: 4F0-910-181.LBL Part No SW: 4F0 910 181 E HW: 4F0 915 181 A Component: ENERGIEMANAGER H11 0400 Part No: 4F0 915 105 C Component: von VA0 2409200295 Coding: 344630393135313035432056413032343039323030323935 Shop #: WSC 00000 No fault code found. ------------------------------------------------------------------------------- Address 62: Door,Rear Left Labels: 4F0-910-795.LBL Part No SW: 4F0 910 795 HW: 4F0 959 795 Component: TSG HL H09 0010 Coding: 0035370 Shop #: WSC 02327 No fault code found. ------------------------------------------------------------------------------- Address 72: Door, Rear Right Labels: 4F0-910-795.LBL Part No SW: 4F0 910 795 HW: 4F0 959 794 Component: TSG HR H09 0010 Coding: 0035370 Shop #: WSC 02327 No fault code found. ------------------------------------------------------------------------------- Address 77: Telephone Labels: 4E0-910-336.LBL Part No SW: 4F0 910 336 HW: 4E0 862 335 Component: Handyvorb2 H10 0080 Coding: 0010900 Shop #: WSC 02335 No fault code found. End -------------------------------------------------------------------------------------------------- -------------------------------------------------------------------------------------------------------- |
Maybe the VAG Forum?
|
dumb question: do they come back if you clear them?
|
Re: dumb question: do they come back if you clear them?
Yes, they do come back.
|
Re: Maybe the VAG Forum?
Thanks. I'll post there as well.
|
The '07 engine is an FSI. How was the conversion done? Tell me you didn't use
the harness and the ECM from the '07.
|
Both the 05 and the 07 3.2 engines are FSI. The switch was the 4.2
|
Re: The '07 engine is an FSI. How was the conversion done? Tell me you didn't use
I used the original harness that was in the 2005 and the ecm from the 2007. I could not use the ecm from the 2005 becaause it was damaged from the collision.
|
Re: Both the 05 and the 07 3.2 engines are FSI. The switch was the 4.2
That is correct. The only difference was the mounting bracket for the power steering pump. Also the 05 has xenon tracking headlamps and the 07 front clip that I purchased had halogen lamps. The left headlamp on the car was good but I had to sell the pair of halogen lamps and purchase a replacement right xenon headlamp.
|
All right, If your sure that everything is coded correctly, then I would assume that the '07 was in
accident as well and may have damaged the intake flap. Bentley would have a procedure to help determine if the part was defective. I would start there. If the part checks out, you know where to go next.
The trans code - isn't the up/down switch in the console? again could have been damaged in the accident - but I see your also getting a CAN bus fault. I myself would start assuming that you overlooked a damaged harness somewhere. |
All times are GMT -8. The time now is 06:32 PM. |
© 2024 MH Sub I, LLC dba Internet Brands